Right Crete Horizontal Repair

Right Crete Horizontal Repair
Flowable Rapid Patch


 

  Right Crete Horizontal Repair
SDSspacerPDF

 

DESCRIPTION
RIGHT CRETE HORIZONTAL REPAIR is a high strength, flowable rapid setting cement. RIGHT CRETE HORIZONTAL REPAIR achieves high early strengths, 2000 PSI in one (1) hour. After one (1) hour repaired areas may be opened up for use.

USE AND APPLICATIONS
• Highways • Floors
• Roadways • Loading docks
• Bridge decks • Sidewalks

FEATURES AND BENEFITS
• Economical to use
• Cement based, no dangerous chemicals
• Just add water and pour
• Sets in 8 to 12 minutes
• May be extended for deep fills

PACKAGING
• 50 lb Bag

Coverage Rate
• One (1) 50 lb bag will yield approximately .50 cubic feet

APPEARANCE
• Concrete gray

SHELF LIFE
• Minimum of one (1) year stored in dry protected storage

DIRECTIONS FOR USE
Proper surface prep for all horizontal materials is critical. Surface must be clean from dirt, grease, oils and other contaminants. Loose concrete must be removed until a sound substrate is exposed. Pre-wet the area to a surface saturated dry (SSD) condition.

MIXING
Mix with 4.5–5 quarts of water. Using a slow speed jiffy mixer, mix for 3 minutes until lump free.

APPLICATION
Simply mix and pour into the prepared saw cut area. Screed to level and finish with a steel trowel.

CLEAN UP
Clean tools with water immediately after use.

Restrictions
Do not re-temper.
Do not exceed 4 1/2 quarts of water per bag.
Do not apply under 35 degrees.
Do saw cut to 1 inch.
Do pre-wet the surface.

 
 

MATERIAL PROPERTIES

ASTM C109
Compressive Strength, PSI
  1 Hour 2000
  24 Hour 3170
  7 Day 4850
  28 Day 6300
ASTM C266
Set Time, Gilmore
  Final 8-10 Min
ASTM C78
Flexural Strength, PSI
  24 Hour 510
  7 Day 890
  28 Day 948
ASTM C666
Freeze thaw Durability Factor
  310 Cycles 96.00%
ASTM C672
Scaling Resistance
  25 Cycles 0% Loss
RIGHT CRETE HORIZONTAL REPAIR mees or exceeds requirements of ASTM C928.

TECHNICAL SERVICE
For conditions not specified, application procedures not noted, contact: Right Pointe, LLC (888) 755-5700.

LIMITED WARRANTY
Every reasonable effort is made to apply Right Pointe, LLC exacting standards both in the manufacture of our products and in the information which we issue concerning these products and their use. We warrant our products to be of good quality and will replace or, at our election, refund the purchase price of any products proved defective. Satisfactory results depend not only upon quality products, but also upon many factors beyond our control. Therefore, except for such replacement or refund, Right Pointe, LLC MAKES NO WARRANTY OR GUARANTEE, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF FITNESS FOR A PARTICULAR PURPOSE OR MERCHANTABILITY, RESPECTING ITS PRODUCTS, and Right Pointe, LLC shall have no other liability with respect thereto. Any claim regarding product defect must be received in writing within one (1) year from the date of shipment. No claim will be considered without such written notice or after the specified time interval. User shall determine the suitability of the products for the intended use and assume all risks and liability in connection therewith. Any authorized change in the printed recommendations concerning the use of our products must bear the signature of the Right Pointe, LLC Technical Manager.

 

 
   

ABOUT US

 

OUR PRODUCTS
Expansion Joints and Plastics
Waterproofing

Joint Sealants
Chemical Liquids
Cementitous Products
Roofing

 

CONTACT US

 

FEATURED PRODUCTS

 

CAREERS

 
© 2017-2019 All Rights Reserved Right Pointe, LLC.