Emulsion Dampproofing
Dampproofing Emulsion


 

  Dampproofing Emulsion
SDSspacerPDF

 

DESCRIPTION
Right Pointe Dampproofing-Emulsion consists of a non-asbestos fiber filled emulsified asphalt that is applied by spray or brush. It provides a thick, extremely smooth dampproof coating for below grade masonry block or poured concrete walls. Unlike solvent-based materials, it has the advantage of being applied over a damp or green surface.

SPECIFICATIONS
• ASTM D-1227, Type II

PACKAGING
• 5 Gallon Pail

APPLICATION
Before application be sure all voids, cracks and rod holes are repaired with plastic sealer. Surface may be damp but free of oils, dirt or anything that may interfere with the adhesion of this product. It is most important that there is no forecast rain during application. In order for this material to set the temperature must be 50° F and rising. This material is compatible with most insulation boards. Check with board manufacturer before application. Allow two days cure time before back filling.

Coverage Rate
One coat application, approximately 30 sq ft/gal. Coverage may be less depending greatly on the porosity of the surface.

STORAGE
PROTECT FROM FREEZING. Keep from open flame. When container is not in use be sure cover is securely fastened. If winter storage is necessary maintain temperature at 50° F or above. Keep stored material off floor. To insure fresh material, rotate stock.

PHYSICAL PROPERTIES
Weight Per Gallon (approximate)..............................................................8.3 lbs
Percent Non-Volatile....................................................................................50% +
Percent Asphalt............................................................................................45% +
Percent Total Solids, by Volume................................................................53% +
Viscosity.................................................................................10000 – 15000 cps
Ash on Basis of Non-Volatile Material......................................................5% Min
Penetration of Base Asphalt (ASTM D 5)..............................................60 - 100
Flash Point of Base Asphalt, C.O.C.F.........................................................450 +
Ductility of Base Asphalt.................................................................................100+
Film Thickness of 1 gallon/ 25 sq ft..........................................................1/16 inch

 

 

 
 

TECHNICAL SERVICE
For conditions not specified, application procedures not noted, contact: Right Pointe, LLC. (888) 755-5700.

LIMITED WARRANTY
Every reasonable effort is made to apply Right Pointe, LLC. exacting standards both in the manufacture of our products and in the information which we issue concerning these products and their use. We warrant our products to be of good quality and will replace or, at our election, refund the purchase price of any products proved defective. Satisfactory results depend not only upon quality products, but also upon many factors beyond our control. Therefore, except for such replacement or refund, Right Pointe, LLC. MAKES NO WARRANTY OR GUARANTEE, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF FITNESS FOR A PARTICULAR PURPOSE OR MERCHANTABILITY, RESPECTING ITS PRODUCTS, and Right Pointe, LLC. shall have no other liability with respect thereto. Any claim regarding product defect must be received in writing within one (1) year from the date of shipment. No claim will be considered without such written notice or after the specified time interval. User shall determine the suitability of the products for the intended use and assume all risks and liability in connection therewith. Any authorized change in the printed recommendations concerning the use of our products must bear the signature of the Right Pointe, LLC. Technical Manager.

 

 

 

 

   

ABOUT US

 

OUR PRODUCTS
Expansion Joints and Plastics
Waterproofing

Joint Sealants
Chemical Liquids
Cementitous Products
Roofing

 

CONTACT US

 

FEATURED PRODUCTS

 
© 2017-2019 All Rights Reserved Right Pointe, LLC.